Contents

Range (aeronautics)

Distance an aircraft can fly between takeoff and landing

The maximal total range is the maximum distance an aircraft can fly between takeoff and landing, as limited by fuel capacity in powered aircraft, or cross-country speed and environmental conditions in unpowered aircraft. The range can be seen as the cross-country ground speed multiplied by the maximum time in the air. The fuel time limit for powered aircraft is fixed by the fuel load and rate of consumption. When all fuel is consumed, the engines stop and the aircraft will lose its propulsion.

Ferry range means the maximum range that a aircraft engaged in ferry flying can achieve. This usually means maximum fuel load, optionally with extra fuel tanks and minimum equipment. It refers to transport of aircraft without any passengers or cargo.

Combat radius is a related measure based on the maximum distance a warplane can travel from its base of operations, accomplish some objective, and return to its original airfield with minimal reserves.

Derivation

For most unpowered aircraft, the maximum flight time is variable, limited by available daylight hours, aircraft design (performance), weather conditions, aircraft potential energy, and pilot endurance. Therefore, the range equation can only be calculated exactly for powered aircraft. It will be derived for both propeller and jet aircraft. If the total mass ${\displaystyle W}$ of the aircraft at a particular time ${\displaystyle t}$ is:

${\displaystyle W}$ = ${\displaystyle W_{0}+W_{f}}$,

where ${\displaystyle W_{0}}$ is the zero-fuel mass and ${\displaystyle W_{f}}$ the mass of the fuel, the fuel consumption rate per unit time flow ${\displaystyle F}$ is equal to

${\displaystyle -{\frac {dW_{f}}{dt}}=-{\frac {dW}{dt}}}$.

The rate of change of aircraft mass with distance ${\displaystyle R}$is

${\displaystyle {\frac {dW}{dR}}={\frac {\frac {dW}{dt}}{\frac {dR}{dt}}}=-{\frac {F}{V}}}$,

where ${\displaystyle V}$ is the speed), so that

${\displaystyle {\frac {dR}{dt}}=-{\frac {V}{F}}{\frac {dW}{dt}}}$

It follows that the range is obtained from the definite integral below, with ${\displaystyle t_{1}}$ and ${\displaystyle t_{2}}$ the start and finish times respectively and ${\displaystyle W_{1}}$ and ${\displaystyle W_{2}}$ the initial and final aircraft masses

${\displaystyle R=\int _{t_{1}}^{t_{2}}{\frac {dR}{dt}}dt=\int _{W_{1}}^{W_{2}}-{\frac {V}{F}}dW=\int _{W_{2}}^{W_{1}}{\frac {V}{F}}dW\quad \quad ($1)}

Specific range

The term ${\displaystyle {\frac {V}{F}}}$, where ${\displaystyle V}$ is the speed, and ${\displaystyle F}$ is the fuel consumption rate, is called the specific range (= range per unit mass of fuel; S.I. units: m/kg). The specific range can now be determined as though the airplane is in quasi steady-state flight. Here, a difference between jet and propeller driven aircraft has to be noticed.

Propeller aircraft

With propeller driven propulsion, the level flight speed at a number of airplane weights from the equilibrium condition ${\displaystyle P_{a}=P_{r}}$ has to be noted. To each flight velocity, there corresponds a particular value of propulsive efficiency ${\displaystyle \eta _{j}}$ and specific fuel consumption ${\displaystyle c_{p}}$. The successive engine powers can be found:

${\displaystyle P_{br}={\frac {P_{a}}{\eta _{j}}}}$

The corresponding fuel weight flow rates can be computed now:

${\displaystyle F=c_{p}P_{br}}$

Thrust power, is the speed multiplied by the drag, is obtained from the lift-to-drag ratio:

${\displaystyle P_{a}=V{\frac {C_{D}}{C_{L}}}Wg}$ ; here Wg is the weight (force in newtons, if W is the mass in kilograms); gisstandard gravity (its exact value varies, but it averages 9.81 m/s²).

The range integral, assuming flight at constant lift to drag ratio, becomes

${\displaystyle R={\frac {\eta _{j}}{gc_{p}}}{\frac {C_{L}}{C_{D}}}\int _{W_{2}}^{W_{1}}{\frac {dW}{W}}}$

To obtain an analytic expression for range, it has to be noted that specific range and fuel weight flow rate can be related to the characteristics of the airplane and propulsion system; if these are constant:

${\displaystyle R={\frac {\eta _{j}}{gc_{p}}}{\frac {C_{L}}{C_{D}}}\ln {\frac {W_{1}}{W_{2}}}}$

Electric aircraft

An electric aircraft with battery power only will have the same mass at takeoff and landing. The logarithmic term with weight ratios is replaced by the direct ratio between ${\displaystyle W_{battery}/W_{total}}$

${\displaystyle R=E^{*}{\frac {1}{g}}\eta _{total}{\frac {L}{D}}{\frac {W_{battery}}{W_{total}}}}$

where ${\displaystyle E^{*}}$ is the energy per mass of the battery (e.g. 150-200 Wh/kg for Li-ion batteries), ${\displaystyle \eta _{total}}$ the total efficiency (typically 0.7-0.8 for batteries, motor, gearbox and propeller), ${\displaystyle L/D}$ lift over drag (typically around 18), and the weight ratio ${\displaystyle {\frac {W_{battery}}{W_{total}}}}$ typically around 0.3.^[1]

Jet propulsion

The range of jet aircraft can be derived likewise. Now, quasi-steady level flight is assumed. The relationship ${\displaystyle D={\frac {C_{D}}{C_{L}}}W}$ is used. The thrust can now be written as:

${\displaystyle T=D={\frac {C_{D}}{C_{L}}}W}$ ; here W is a force in newtons

Jet engines are characterized by a thrust specific fuel consumption, so that rate of fuel flow is proportional to drag, rather than power.

${\displaystyle F=c_{T}T=c_{T}{\frac {C_{D}}{C_{L}}}W}$

Using the lift equation, ${\displaystyle {\frac {1}{2}}\rho V^{2}SC_{L}=W}$

where ${\displaystyle \rho }$ is the air density, and S the wing area.

the specific range is found equal to:

${\displaystyle {\frac {V}{F}}={\frac {1}{c_{T}}}{\sqrt {{\frac {C_{L}}{C_{D}^{2}}}{\frac {2}{\rho SW}}}}}$

Inserting this into (1) and assuming only ${\displaystyle W}$ is varying, the range (in meters) becomes:

${\displaystyle R={\frac {1}{c_{T}}}{\sqrt {{\frac {C_{L}}{C_{D}^{2}}}{\frac {2}{g\rho S}}}}\int _{W_{2}}^{W_{1}}{\frac {1}{\sqrt {W}}}dW}$ ; here ${\displaystyle W}$ is again mass.

When cruising at a fixed height, a fixed angle of attack and a constant specific fuel consumption, the range becomes:

${\displaystyle R={\frac {2}{c_{T}}}{\sqrt {{\frac {C_{L}}{C_{D}^{2}}}{\frac {2}{g\rho S}}}}\left({\sqrt {W_{1}}}-{\sqrt {W_{2}}}\right)}$

where the compressibility on the aerodynamic characteristics of the airplane are neglected as the flight speed reduces during the flight.

Cruise/climb

For long range jet operating in the stratosphere (altitude approximately between 11 and 20 km), the speed of sound is constant, hence flying at fixed angle of attack and constant Mach number causes the aircraft to climb, without changing the value of the local speed of sound. In this case:

${\displaystyle V=aM}$

where ${\displaystyle M}$ is the cruise Mach number and ${\displaystyle a}$ the speed of sound. W is the weight in kilograms (kg). The range equation reduces to:

${\displaystyle R={\frac {aM}{gc_{T}}}{\frac {C_{L}}{C_{D}}}\int _{W_{2}}^{W_{1}}{\frac {dW}{W}}}$

where ${\displaystyle a={\sqrt {{\frac {7}{5}}R_{s}T}}}$ ; here ${\displaystyle R_{s}}$is the specific heat constant of air 287.16 ${\displaystyle {\frac {J}{kgK}}}$ (based on aviation standards) and ${\displaystyle \gamma =7/5=1.4}$ (derived from ${\displaystyle \gamma ={\frac {c_{p}}{c_{v}}}}$ and ${\displaystyle c_{p}=c_{v}+R_{s}}$). ${\displaystyle c_{p}}$ and ${\displaystyle c_{v}}$ are the specific heat capacities of air at a constant pressure and constant volume respectively.

Or${\displaystyle R={\frac {aM}{gc_{T}}}{\frac {C_{L}}{C_{D}}}ln{\frac {W_{1}}{W_{2}}}}$, also known as the Breguet range equation after the French aviation pioneer, Breguet.

Modified Breguet range equation

It is possible to improve the accuracy of the Breguet range equation by recognizing the limitations of the conventionally used relationships for fuel flow:

${\displaystyle F=c_{T}T=c_{T}{\frac {C_{D}}{C_{L}}}W}$

In the Breguet range equation, it is assumed that the thrust specific fuel consumption is constant as the aircraft weight decreases. This is generally not a good approximation because a significant portion (e.g. up to 10%) of the fuel flow does not produce thrust and is instead required for engine "accessories" such as hydraulic pumps, electrical generators, and bleed air powered pressurization systems.

We can account for this by extending the assumed fuel flow formula in a simple way where an "adjusted" virtual aircraft weight ${\displaystyle {\widehat {W}}}$ is defined by adding a constant additional "accessory" weight ${\displaystyle W_{acc}}$.

${\displaystyle {\widehat {W}}=W+W_{acc}}$

${\displaystyle F={\widehat {c}}_{T}{\frac {C_{D}}{C_{L}}}{\widehat {W}}}$

Here, the thrust specific fuel consumption has been adjusted down and the virtual aircraft weight has been adjusted up to maintain the proper fuel flow while making the adjusted thrust specific fuel consumption truly constant (not a function of virtual weight).

Then, the modified Breguet range equation becomes

${\displaystyle R={\frac {aM}{g{\widehat {c}}_{T}}}{\frac {C_{L}}{C_{D}}}ln{\frac {{\widehat {W}}_{1}}{{\widehat {W}}_{2}}}}$

The above equation combines the energy characteristics of the fuel with the efficiency of the jet engine. It is often useful to separate these terms. Doing so completes the nondimensionalization of the range equation into fundamental design disciplines of aeronautics.

${\displaystyle R=Z_{f}{\frac {aM}{Z_{f}g{\widehat {c}}_{T}}}{\frac {C_{L}}{C_{D}}}ln{\frac {{\widehat {W}}_{1}}{{\widehat {W}}_{2}}}}$

where 
 
${\displaystyle Z_{f}}$ is the geopotential energy height of the fuel (km)
 
${\displaystyle {\frac {aM}{Z_{f}g{\widehat {c}}_{T}}}}$ is the overall engine efficiency (nondimensional) ${\displaystyle \eta _{eng}}$
 
${\displaystyle {\frac {C_{L}}{C_{D}}}}$ is the aerodynamic efficiency (nondimensional) ${\displaystyle \eta _{aero}}$
 
${\displaystyle ln{\frac {{\widehat {W}}_{1}}{{\widehat {W}}_{2}}}}$ is the structural efficiency (nondimensional) ${\displaystyle \eta _{struc}}$

giving the final form

${\displaystyle R=Z_{f}\eta _{eng}\eta _{aero}\eta _{struc}}$

The geopotential energy height of kerosene jet fuel is 4400 km or 11% of the Earth's circumference. A physical interpretation is the height that a quantity of fuel could lift itself in the Earth's (assumed constant) gravity field by converting its chemical energy into potential energy. Assuming an overall engine efficiency of 40%, a lift-to-drag ratio of 18:1, and a structural efficiency of 50%, the cruise range would be

${\displaystyle R=(4400km)(40\%)($18)(50\%)=15,840km}

See also

• Flight length
• Flight distance record
• Endurance
• Energy conversion efficiency
• Geopotential altitude
• Jet engine performance
• Lift-to-drag ratio
• Fuel fraction

References

• G. J. J. Ruijgrok. Elements of Airplane Performance. Delft University Press. ^{[page needed]} ISBN 9789065622044.
• Prof. Z. S. Spakovszky. Thermodynamics and Propulsion, Chapter 13.3 Aircraft Range: the Breguet Range Equation MIT turbines, 2002
• Martinez, Isidoro. http://imartinez.etsiae.upm.es/~isidoro/bk3/c17/Aircraft%20propulsion.pdf#page29 Aircraft propulsion. Range and endurance: Breguet's equation page 25.
• Marchman, James, III. (2021). Aerodynamics and Aircraft Performance. Blacksburg: VA: University Libraries at Virginia Tech. http://hdl.handle.net/10919/96525 CC BY 4.0.