Contents

FedEx Express Flight 14

FedEx Express Flight 14

The wreckage of Flight 14 after the fire was extinguished
Accident
Date	July 31, 1997 (1997-07-31)
Summary	Crashed on landing due to pilot error
Site	Newark International Airport runway 22R, Newark, New Jersey, United States 40°41′14″N 74°10′27″W / 40.6872°N 74.1742°W / 40.6872; -74.1742
Aircraft
Aircraft type	McDonnell Douglas MD-11F
Aircraft name	Joshua
Operator	FedEx Express
IATA flight No.	FX14
ICAO flight No.	FDX14
Call sign	FEDEX 14
Registration	N611FE
Flight origin	Singapore Changi Airport, Singapore
1st stopover	Penang International Airport, Penang, Malaysia
2nd stopover	Taiwan Taoyuan International Airport, Taipei, Taiwan
Last stopover	Anchorage International Airport, Anchorage Alaska, United States
Destination	Newark International Airport, Newark, New Jersey, United States
Occupants	5
Passengers	3
Crew	2
Fatalities	0
Injuries	5
Survivors	5

FedEx Express Flight 14 was a scheduled cargo flight from SingaporetoNewark, New Jersey, via Malaysia, Taiwan, and Alaska. On July 31, 1997, the aircraft flying this route crashed during landing on its final segment at Newark International Airport (EWR), inverting and catching fire, injuring all five people on board.^[1]

Flight 14 crashed while landing on runway 22R at Newark Airport on July 31, 1997. The flight originated in Singapore with intermediate stops in Penang, Malaysia, followed by Taipei, Taiwan, and then Anchorage, Alaska. In addition to the Captain and First Officer there were three passengers on board, including one riding in the jump seat.

During the flight, the pilots were concerned that they would have little stopping distance after landing, and the captain said that he wanted to put the aircraft down early on the runway. The aircraft had departed with one thrust reverser (on the left engine) inoperative, and the pilots knew of incidents in the aircraft's maintenance log where the auto-brakes had failed to activate during landings. They had also misinterpreted the runway data, and so believed they had less stopping distance than was actually available.^[2][3]

The landing was normal until the beginning of the flare phase. The MD-11 touched down, bounced, and rolled to the right. On the second touchdown, about 1,100 feet (340 m) later, the right gear snapped and the No. 3 engine (right wing engine) contacted the runway, with the right roll continuing until the right wing spars broke. The aircraft came to rest off the right side of the runway, on its back, and on fire. All five occupants escaped through a cockpit window. The airplane was destroyed by fire.^[3][4]

The aircraft, named Joshua by FedEx, construction number 48603 and line number 553, was a McDonnell Douglas MD-11F freight model, powered by three General Electric CF6-80C2D1F engines. Registered in the United States as N611FE,^[5] the aircraft was delivered new to FedEx in September 1993. Prior to the crash, the aircraft had a total of 13,034 flight hours and 2,950 flight cycles (a flight cycle is defined as a takeoff and landing), and had been involved in two prior incidents. In January 1994, when it sustained underbelly damage during a bounced landing at Memphis International Airport. Then in November 1994, the aircraft was involved in a tailstrikeatAnchorage International Airport. Permanent repairs were made from the Anchorage incident within days of the tailstrike, and permanent repairs to the Memphis incident were made at the next C check in August 1995.^[2]

The captain was 46-year-old Robert M. Freeman who joined FedEx in 1988 when it bought Flying Tiger Line, which he had previously worked for since 1978. Freeman had logged a total of 11,000 flight hours, including 1,253 hours on the MD-11. The first officer was 39-year-old Donald E. Goodin, who had been with FedEx since 1994, having served as a former U.S. Air Force pilot from 1977 to 1994 and had 3,703 flight hours, though only 592 of them were with FedEx. Goodin only had 95 hours on the MD-11.^{[2]: 11–12 [6][7][8]}

The National Transportation Safety Board (NTSB) conducted a full investigation of the accident and concluded that the probable cause was the captain's over-control of the aircraft during the landing and his failure to go around after a destabilized flare. Beginning about 17 feet (5.2 m) above the runway, the captain had let the nose lower, probably to achieve an earlier touchdown, then raised it and increased thrust to slow the plane's descent, then pushed the nose down again (around the time of the first touchdown) to try to keep the plane on the runway. These last control inputs were "too late and too large" to stabilize the landing, and the plane's high sink rate and rightward roll compressed the right landing gear strut at the second touchdown, which broke the right wing rear spar and ruptured the right fuel tank.^[2][3][4]

As a result of its investigation of this accident, the NTSB made new recommendations based on their findings and conclusions to improve the safety of operations of the MD-11 type aircraft including that the FAA develop new pilot training tools to "include information about factors that can contribute to structural failures involving the landing gear, wings, and fuselage, such as design sink rate limits; roll angle limits; control inputs' roll rate; pitch rate; single-gear landings; the effect of decreased lift; and structural loading consequences of bottoming landing gear struts and tires; provide a syllabus for simulator training on the execution of stabilized approaches to the landing flare, the identification of unstabilized landing flares, and recovery from these situations, including proper high sink rate recovery techniques during flare to landing, techniques for avoiding and recovering from overcontrol in pitch before touchdown, and techniques for avoiding overcontrol and premature derotation during a bounced landing; and to promote an orientation toward a proactive go-around."^[2][3][4]

For his role in the accident, Captain Freeman was fired from FedEx on October 30, 2000. However, the FedEx pilot union criticized the decision and announced that they would appeal it, citing that the crash was caused by aircraft design flaws.^[9]

The crashes of FedEx Express Flight 14, and a similar crash in 2009 of another McDonnell Douglas MD-11, FedEx Express Flight 80atNarita International Airport in Japan, are both covered on Season 14 of Mayday (Air Crash Investigation, Air Disasters), episode 5, titled "The Final Push".^[10]

• FedEx Express Flight 80 – an MD-11 that bounced and flipped on landing in 2009
• Fine Air Flight 101 - a DC-8 freighter that crashed a week later in Miami
• List of accidents and incidents involving commercial aircraft

 This article incorporates public domain material from websites or documents of the National Transportation Safety Board.

• NTSB investigation docket
• Accident description at the Aviation Safety Network