Accident | |
---|---|
Date | 1 November 2011 (2011-11-01) |
Summary | Belly landing following hydraulic failure |
Site | Warsaw Chopin Airport, Warsaw, Poland 52°09′56″N 20°58′02″E / 52.16556°N 20.96722°E / 52.16556; 20.96722 |
Aircraft | |
The Boeing 767 involved in the accident | |
Aircraft type | Boeing 767-35D(ER) |
Aircraft name | Poznań |
Operator | LOT Polish Airlines |
IATA flight No. | LO16 |
ICAO flight No. | LOT16 |
Call sign | LOT 16 |
Registration | SP-LPC |
Flight origin | Newark Liberty International Airport, Newark, New Jersey, U.S. |
Destination | Warsaw Chopin Airport, Warsaw, Poland |
Occupants | 231 |
Passengers | 220 |
Crew | 11 |
Fatalities | 0 |
Survivors | 231 |
LOT Polish Airlines Flight 16 was a Boeing 767 passenger jet on a scheduled service from Newark, United States, to Warsaw, Poland, that on 1 November 2011 made a successful gear-up emergency landingatWarsaw Chopin Airport, after its landing gear failed to extend. All 231 aboard survived without serious injuries. A leak in one of the aircraft's hydraulic systems occurred shortly after takeoff, resulting in the loss of all of the hydraulic fluid supplying the primary landing gear system.[1]
The aircraft involved was a Boeing 767-35DER, registered as SP-LPC, named Poznań, serial number 28656. It was built by Boeing Commercial Airplanes in 1997 and in its 14 years of service, it had logged onto approximately 85429 airframe hours and 8002 takeoff and landing cycles. The aircraft was also equipped with two General Electric CF6-80C2B6 engines.[2]
LOT Polish Airlines Flight 16 was scheduled to arrive at Warsaw Chopin Airport from Newark Liberty International Airport on 1 November 2011 at 13:35 CET with 220 passengers and 11 crew on board.[3]
Within 30 minutes of departing from Newark, the crew received a warning that the center hydraulic system had malfunctioned.[4] The decision was made to continue to Warsaw in order to use up the heavy load of fuel needed for the transatlantic flight.[5] The aircraft proceeded to approach as normal, but aborted when the landing gear failed to deploy.[6]
The crew informed Warsaw air traffic control (ATC) that they were unable to lower the landing gear due to a hydraulic system failure. The captain decided to circle the airport for over an hour, to consume excess fuel and to allow time for ground emergency services to prepare for the landing, including covering the runway with a fire suppression foam.[7] Visual observation by two Polish Air Force F-16 fighter jets verified that none of the landing gear were down; attempts to lower the landing gear by alternative means failed.[8][9]
The airport was evacuated for the arrival of the aircraft, and roads around the airport were closed to accommodate emergency services. Other flights which were due into Warsaw were diverted or returned to their point of departure.[9]
At 14:40 CET the crew made a successful gear-up landing on Runway 33, with no injuries to anyone. The aircraft however, sustained substantial damage, resulting in a hull loss. All of those on board were evacuated within 90 seconds.[10]
The airport remained closed to traffic until 16:00 CET, 3 November 2011, to enable removal of crash debris and then a final inspection of runways and aprons.[11]
Shortly after the evacuation, a team from the Polish State Commission on Aircraft Accidents Investigation (SCAAI) discovered that the C829 circuit breaker, which protects a number of systems including the alternate landing gear extension system, was "popped", or opened, interrupting the circuit. The C4248 breaker for the alternate landing gear system remained closed.
After the plane was lifted off the runway, the C829 circuit breaker was closed, and the landing gear was extended using the alternate system. The plane was then towed to the LOT maintenance hangar[12] for further investigation.[13][14]
The captain of Flight 16 was Tadeusz Wrona, a 57-year-old veteran pilot with twenty years of experience on the 767. Both the captain and 51-year-old first officer Jerzy Szwarc held Airline Transport Pilot Licenses, accumulating over 25,000 hours of flying time between them, of which 15,000 were on 767 aircraft. After that situation new proverb was created『Leć jak Orzeł, ląduj jak Wrona』(Fly like an eagle, land like a crow) [15][12]
The preliminary report by the SCAAI found that a hydraulic leak occurred shortly after takeoff, after the landing gear and flaps were retracted.[16] The leak was caused by excessive bending of a flexible hose in the center hydraulic system, resulting in the loss of all fluid in that system. The drop in pressure was indicated by the EICAS and recorded by the flight data recorder.[12][17] Later investigation indicated a popped circuit breaker just to the right of the F/O at floor level would have enabled the electric motor for releasing the undercarriage. The breaker was reset after landing and the undercarriage extended normally.[10]
The final report of the accident was released in 2017. The causes of the accident were the center hydraulic hose leak, the C829 circuit breaker popping, and the flight crew's failure to detect the C829 breaker during the approach, which could have allowed them to lower the landing gear. Contributing factors were the lack of safeguards to prevent accidental opening of circuit breakers, the C829 circuit breaker being in a low position where the flight crew would have difficulty noticing its condition, LOT's operations center inadequate procedures, and LOT's failure to incorporate a Boeing service bulletin on the prevention of excessive bending in the hydraulic system hose.[18]
Polish President Bronisław Komorowski praised and thanked the crew for the successful landing.[19] The Boeing 767, registration SP-LPC, was extensively damaged and LOT deemed the aircraft a hull loss.[20] The accident represents the 14th hull loss of a Boeing 767.[21] In November 2013, two years after the incident, the aircraft was scrapped.[22] As of August 2022, the flight was operated by the Boeing 787. LOT ended its Boeing 767 services by 2013, replacing them with the Boeing 787.[23]
{{cite web}}
: CS1 maint: numeric names: authors list (link)
External media | |
---|---|
Images | |
"Photograph of aircraft coming to rest". Aircraft-spotting.org. 1 November 2011. Retrieved 4 November 2011. | |
Airliners.net photo | |
Video | |
OKĘCIE LĄDOWANIE AWARYJNE POLISH AIRLINES LOT BOEING 767 EMERGENCY LANDING WARSAW (in Polish). | |
Boeing 767 Newark-Warsaw Okecie LOT accident landing 01.11.11 (in Polish). 1 November 2011. |
Aviation accidents and incidents in Poland
| |
---|---|
|
Aviation accidents and incidents in 2011 (2011)
| |
---|---|
Jan 1 Jan 9 Feb 10 Feb 14 Central American Airways Flight 731 Mar 5 Garbuzovo Antonov An-148 crash Mar 21 Apr 1 Apr 4 Apr 19 May 7 Merpati Nusantara Airlines Flight 8968 May 18 May 18 Omega Aerial Refueling Services Flight 70 Jun 20 Jul 4 Missinippi Airways Cessna 208 crash Jul 6 Jul 8 Jul 11 Jul 13 Noar Linhas Aéreas Flight 4896 Jul 26 Royal Moroccan Air Force C-130 crash Jul 28 Jul 29 Jul 30 Aug 6 Aug 9 Aug 14 South Africa Piaggio Albatross crash Aug 20 Sep 2 Sep 6 Sep 7 Lokomotiv Yaroslavl charter plane crash Sep 16 Sep 25 Sep 29 Nusantara Buana Air Flight 823 Oct 13 Oct 14 Oct 18 Nov 1 Nov 11 Dec 10 Manila Beechcraft Queen Air crash | |